2016 Volvo XC60

Problems, Recalls & Reliability Report

Above Average

Quick Summary

The 2016 Volvo XC60 has 45 owner complaints filed with NHTSA — that's 0.6x the segment average of 80. The most common issue is engine problems (36% of all complaints), specifically: "the contact owns a 2016 volvo xc60. the contact stated that while driving at 25 mph, the oil warning light illuminated. the contact stated that she refilled the oil when she arrived at her residence. the contact noticed that the vehicle was consuming an excessive amount of oil and she was refilling. ⚠️ 1 fire report filed.

1 fire report 4 crash reports

Total Complaints

Recalls Issued

—/5

Safety Stars

0.6x

vs Segment Avg

Known Problems

ENGINE

16 complaints

36%

• "The contact owns a 2016 Volvo XC60. The contact stated that while driving at 25 MPH, the oil warning light illuminated. The contact stated that she refilled the oil when she arrived at her residence. The contact noticed that the vehicle was consuming an excessive amount of oil and she was refilling
• WHEN STOPPED AT A STOP LIGHT, HAVE TO HOLD BRAKE DOWN IN ORDER TO KEEP THE CAR FROM DRIVING AS THE RPMS ARE REVVING UP AND DOWN, CAUSING THE CAR TO WANT TO MOVE AND WHEN IN PARK REVVING SO HIGH THAT IT WENT INTO RED AND CAUSED THE CHECK ENGINE LIGHT TO COME ON AND I HAD TO TURN OFF THE VEHICLE. ALSO
• This car has excessive oil consumption and burns oil because the piston rings are faulty. Eventually can cause the engine to stop working and put lives on the road in danger. This was proven in a class action lawsuit against Volvo and they extended the warranty to 8 years or 100,000 miles however

Typical onset: 50K miles Est. repair: $500

“"The contact owns a 2016 Volvo XC60. The contact stated that while driving at 25 MPH, the oil warning light illuminated. The contact stated that she refilled the oil when she arrived at her residence. The contact noticed that the vehicle was consuming an excessive amount of oil and she was refilling”

— NHTSA complaint filing

OTHER

9 complaints

20%

• THE REARVIEW CAMERA ON THE NEW VOLVO XC 60 2016 IS NOT RELIABLE - IT TENDS TO BECOME EXTREMELY HAZY WITH EVEN A SLIGHT RAINFALL AND PERHAPS THE POSITIONING OF THE CAMERA / THE MATERIAL USED FOR THE LENSES ARE NOT IDEAL. WE HAVE HAD 4 CARS FROM OTHER MANUFACTURERS OVER THE PAST 2-3 YEARS AND NONE OF
• MY CAR STOPPED IN THE MIDDLE OF THE ROAD WITH MY CHILD IN THE CAR; COME TO FIND OUT THEIR IS A STARTER RECALL ASSOCIATED WITH THIS YEAR MAKE AND MODEL, BUT NOT ASSOCIATED WITH MY VIN. AFTER NUMEROUS OTHER BREAK DOWNS THIS WAS CONFIRMED BY A MECHANIC THAT IT IS AN ISSUE. VOLVO STATED THEY COULD NOT
• I DROVE MY CAR TO THE GARAGE AND WANT TO TURN OFF THE CAR. THE CAR SUDDENLY START TO ACCELERATE AND WENT THROUGH MY GARAGE DOOR. ALL SIDE AIRBAGS ARE POPPED UP, BUT NOT FRONT AIRBAG. *DT *AS AROUND A YEAR AGO, WHEN MY DROVE HER CAR SLOWLY DUE TO HEAVY TRAFFIC, THE CAR STOPPED AND NEEDED TO TURN

Typical onset: 50K miles Est. repair: $500🔥 1 fire reports💥 1 crashes

“THE REARVIEW CAMERA ON THE NEW VOLVO XC 60 2016 IS NOT RELIABLE - IT TENDS TO BECOME EXTREMELY HAZY WITH EVEN A SLIGHT RAINFALL AND PERHAPS THE POSITIONING OF THE CAMERA / THE MATERIAL USED FOR THE LENSES ARE NOT IDEAL. WE HAVE HAD 4 CARS FROM OTHER MANUFACTURERS OVER THE PAST 2-3 YEARS AND NONE OF ”

— NHTSA complaint filing

SEATS/RESTRAINTS

7 complaints

16%

• A LETTER WAS SENT FROM VOLVO CORP ABOUT A SAFETY RECALL ON SEATBELTS IN AUGUST 2020 STATING THAT PARTS WOULD BE AVAILABLE AFTER NOV 2020. I CALLED THE LOCAL DEALER LAST WEEK AND APPARENTLY THEY DO NOT HAVE THE PARTS TO MAKE THE NECESSARY REPAIRS. I AM VERY CONCERNED FOR MY SAFETY WHILE DRIVING THI
• TL* THE CONTACT OWNS A 2016 VOLVO XC60. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V378000 (SEAT BELTS) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT CALLED TO GORGES VOLVO CARS (17665 BURT ST, OMAHA, NE 68118; (402) 359-1500) WHERE IT WAS CONFIRMED THAT T
• I RECEIVED A SAFETY RECALL NOTICE IN AUGUST 2020 (FOR A RECALL ISSUED IN JUNE 2020) AND I CONTACTED MY VOLVO DEALER (DON BEYER DULLES, VA), WHO SAID THAT THE PARTS WERE NOT AVAILABLE. I RECEIVED A SECOND SAFETY RECALL NOTICE IN DECEMBER AND I CONTACTED MY VOLVO DEALER, WHO SAID THAT THE PARTS WERE

Typical onset: 50K miles Est. repair: $500

“A LETTER WAS SENT FROM VOLVO CORP ABOUT A SAFETY RECALL ON SEATBELTS IN AUGUST 2020 STATING THAT PARTS WOULD BE AVAILABLE AFTER NOV 2020. I CALLED THE LOCAL DEALER LAST WEEK AND APPARENTLY THEY DO NOT HAVE THE PARTS TO MAKE THE NECESSARY REPAIRS. I AM VERY CONCERNED FOR MY SAFETY WHILE DRIVING THI”

— NHTSA complaint filing

BRAKES

3 complaints

• CITY SAFETY BRAKES FOR NO REASON. WHEN APPLYING THE BRAKES, BRAKES GRAB AND CAR LUNGES FORWARD, SOMETIME THE CITY SAFETY MESSAGE APPEARS AND OTHER TIMES IT DOES NOT. I WAS BREAKING FOR A STOP WHEN THIS HAPPENED. THOUGHT I WAS GOING TO REAR ENDED BECAUSE OF THE SUDDEN STOP. THIS HAS HAPPENED SEVERAL
• TL* THE CONTACT OWNS A 2016 VOLVO XC60. WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE BEGAN TO SHAKE AND THE BRAKES ENGAGED WITHOUT WARNING. THE CONTACT STATED THAT THE FAILURE WAS INTERMITTENT AND OCCURRED TEMPORARILY. VOLVO CARS PRINCETON (2931 BRUNSWICK PIKE, LAWRENCE TOWNSHIP, NEW JERSEY 08648
• I DROVE MY CAR TO THE GARAGE AND WANT TO TURN OFF THE CAR. THE CAR SUDDENLY START TO ACCELERATE AND WENT THROUGH MY GARAGE DOOR. ALL SIDE AIRBAGS ARE POPPED UP, BUT NOT FRONT AIRBAG. *DT *AS AROUND A YEAR AGO, WHEN MY DROVE HER CAR SLOWLY DUE TO HEAVY TRAFFIC, THE CAR STOPPED AND NEEDED TO TURN

Typical onset: 50K miles Est. repair: $500💥 1 crashes

“CITY SAFETY BRAKES FOR NO REASON. WHEN APPLYING THE BRAKES, BRAKES GRAB AND CAR LUNGES FORWARD, SOMETIME THE CITY SAFETY MESSAGE APPEARS AND OTHER TIMES IT DOES NOT. I WAS BREAKING FOR A STOP WHEN THIS HAPPENED. THOUGHT I WAS GOING TO REAR ENDED BECAUSE OF THE SUDDEN STOP. THIS HAS HAPPENED SEVERAL”

— NHTSA complaint filing

ELECTRICAL

3 complaints

• There was (still is) an issue with my 2016 Volvo XC60's electrical wiring. I was driving, about to get onto the highway when my volvo stalled on the on ramp. It wouldn't start, it couldn't be jumped. It had to be towed to the repair shop. They charged me over $1,000.00 for a brand new starter, and a
• Volvo xc60 sunroof drains clog and leak. Sunroof maintenance is not mentioned in owner's manual, and dealer does not clear drains during regular service unless specifically asked to. Leak causes damage to electronic systems including airbag system. While any sunroof has the potential to leak, this l
• appears to be significant electrical issue or internal computer issue causing a safety issue

Typical onset: 50K miles Est. repair: $500

“There was (still is) an issue with my 2016 Volvo XC60's electrical wiring. I was driving, about to get onto the highway when my volvo stalled on the on ramp. It wouldn't start, it couldn't be jumped. It had to be towed to the repair shop. They charged me over $1,000.00 for a brand new starter, and a”

— NHTSA complaint filing

Estimated Repair Costs

ENGINE(~50K mi)

$500

OTHER(~50K mi)

$500

SEATS/RESTRAINTS(~50K mi)

$500

BRAKES(~50K mi)

$500

ELECTRICAL(~50K mi)

$500

Estimates based on average reported repair costs. Actual costs vary by location, shop, and severity.

🔍 Pre-Purchase Inspection Checklist

Based on 45 owner complaints for this specific year, here's what to check or ask about:

☐
ENGINE: "The contact owns a 2016 Volvo XC60. The contact stated that while driving at 25 MPH, the oil warning light illuminated. The contact stated that she refilled the oil when she arrived at her residence. The contact noticed that the vehicle was consuming an excessive amount of oil and she was refilling
Typically appears around 50K miles. Repair cost ~$500
☐
OTHER: THE REARVIEW CAMERA ON THE NEW VOLVO XC 60 2016 IS NOT RELIABLE - IT TENDS TO BECOME EXTREMELY HAZY WITH EVEN A SLIGHT RAINFALL AND PERHAPS THE POSITIONING OF THE CAMERA / THE MATERIAL USED FOR THE LENSES ARE NOT IDEAL. WE HAVE HAD 4 CARS FROM OTHER MANUFACTURERS OVER THE PAST 2-3 YEARS AND NONE OF
Typically appears around 50K miles. Repair cost ~$500
☐
SEATS/RESTRAINTS: A LETTER WAS SENT FROM VOLVO CORP ABOUT A SAFETY RECALL ON SEATBELTS IN AUGUST 2020 STATING THAT PARTS WOULD BE AVAILABLE AFTER NOV 2020. I CALLED THE LOCAL DEALER LAST WEEK AND APPARENTLY THEY DO NOT HAVE THE PARTS TO MAKE THE NECESSARY REPAIRS. I AM VERY CONCERNED FOR MY SAFETY WHILE DRIVING THI
Typically appears around 50K miles. Repair cost ~$500
☐
BRAKES: CITY SAFETY BRAKES FOR NO REASON. WHEN APPLYING THE BRAKES, BRAKES GRAB AND CAR LUNGES FORWARD, SOMETIME THE CITY SAFETY MESSAGE APPEARS AND OTHER TIMES IT DOES NOT. I WAS BREAKING FOR A STOP WHEN THIS HAPPENED. THOUGHT I WAS GOING TO REAR ENDED BECAUSE OF THE SUDDEN STOP. THIS HAS HAPPENED SEVERAL
Typically appears around 50K miles. Repair cost ~$500
☐
General: Get a pre-purchase inspection from an independent mechanic ($100-$200)