2015 Ram 5500

Problems, Recalls & Reliability Report

Excellent Reliability

Quick Summary

The 2015 Ram 5500 has 20 owner complaints filed with NHTSA — that's 0.3x the segment average of 80. The most common issue is engine problems (25% of all complaints), specifically: tl* the contact owns a 2015 ram 5500. upon inspection, the contact noticed coolant leaking from the vehicle. the vehicle was taken to fields chrysler jeep dodge-sanford (750 towne center blvd, sanford, fl), but a leak could not be found. afterwards, the low coolant indicator illuminated. the contact. ⚠️ 1 fire report filed.

1 fire report

Total Complaints

Recalls Issued

—/5

Safety Stars

0.3x

vs Segment Avg

Known Problems

ENGINE

5 complaints

25%

• TL* THE CONTACT OWNS A 2015 RAM 5500. UPON INSPECTION, THE CONTACT NOTICED COOLANT LEAKING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO FIELDS CHRYSLER JEEP DODGE-SANFORD (750 TOWNE CENTER BLVD, SANFORD, FL), BUT A LEAK COULD NOT BE FOUND. AFTERWARDS, THE LOW COOLANT INDICATOR ILLUMINATED. THE CONTACT
• VEHICLE WAS TAKEN TO THE DEALERSHIP DUE TO AN ISSUE WHERE WHITE SMOKE WOULD APPEAR WHEN THE ENGINE IS UNDER LOAD. DEALER WAS UNABLE TO REPAIR THE ISSUE DUE TO SCHEDULING CONFLICTS. OWNER ATTEMPTED TO DRIVE THE VEHICLE TO ANOTHER LOCATION FOR DIAGNOSTICS. VEHICLE CAUGHT ON FIRE ON THE WAY TO ANOTHER
• THE DPF FILTER IS SAYING THAT ITS CLOGGED AND IT WON'T REGIN. CODES: P0234, P24A2,P0420,P0087,P2228,P1193,P243F,P0102,P203F,P2280

Typical onset: 50K miles Est. repair: $500🔥 1 fire reports

“TL* THE CONTACT OWNS A 2015 RAM 5500. UPON INSPECTION, THE CONTACT NOTICED COOLANT LEAKING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO FIELDS CHRYSLER JEEP DODGE-SANFORD (750 TOWNE CENTER BLVD, SANFORD, FL), BUT A LEAK COULD NOT BE FOUND. AFTERWARDS, THE LOW COOLANT INDICATOR ILLUMINATED. THE CONTACT”

— NHTSA complaint filing

ELECTRICAL

4 complaints

20%

• BATTERY SAVER MODE MSG APPEARED ON DASH. TRUCK HAD 87,000 MILES AND 2400 HOURS. USED AS A ROADSIDE SERVICE WRECKER. TESTED BATTERIES. 1 TESTED BAD. REPLACED BOTH BATTERIES. MESSAGE COMES BACK AT STARTUP ON COLD MORNINGS. MSG STAYS ON UNTIL TRUCK IS WARMED LATER IN THE DAY.
• TRUCK WAS ON HIGHWAY GOING 70 MPH. DRIVER SAID IT STARTED SHAKING VERY HARD AND THEN HEARD A VERY LOUD BANG. WAS ABLE TO KEEP IT UNDER CONTROL AND BRING IT TO A STOP. THERE WERE PARTS OF THE TRANSFER CASE ALL OVER THE ROAD. DRIVE SHAFT WAS BENT AT A 45 DEGREE ANGLE. WIRING WAS WRAPPED AROUND YOK
• THE DPF FILTER IS SAYING THAT ITS CLOGGED AND IT WON'T REGIN. CODES: P0234, P24A2,P0420,P0087,P2228,P1193,P243F,P0102,P203F,P2280

Typical onset: 50K miles Est. repair: $500

“BATTERY SAVER MODE MSG APPEARED ON DASH. TRUCK HAD 87,000 MILES AND 2400 HOURS. USED AS A ROADSIDE SERVICE WRECKER. TESTED BATTERIES. 1 TESTED BAD. REPLACED BOTH BATTERIES. MESSAGE COMES BACK AT STARTUP ON COLD MORNINGS. MSG STAYS ON UNTIL TRUCK IS WARMED LATER IN THE DAY.”

— NHTSA complaint filing

TRANSMISSION

3 complaints

15%

• TRUCK WAS ON HIGHWAY GOING 70 MPH. DRIVER SAID IT STARTED SHAKING VERY HARD AND THEN HEARD A VERY LOUD BANG. WAS ABLE TO KEEP IT UNDER CONTROL AND BRING IT TO A STOP. THERE WERE PARTS OF THE TRANSFER CASE ALL OVER THE ROAD. DRIVE SHAFT WAS BENT AT A 45 DEGREE ANGLE. WIRING WAS WRAPPED AROUND YOK
• HAVE HAD SHIFTING ISSUE'S IN THE PAST, REPAIR UNDER WARRANTY WAS TRANS SOLENOIDS. NOW, OUT OF WARRANTY, IT'S THE TRANS WIRING HARNESS.
• The contact owns a 2015 Ram 5500. The contact stated while driving 69 MPH, the vehicle started vibrating abnormally with abnormal sounds coming from the vehicle. There was no warning light illuminated. The contact was able to park on the side of the road, exited the vehicle, and noticed transmission

Typical onset: 50K miles Est. repair: $500

“TRUCK WAS ON HIGHWAY GOING 70 MPH. DRIVER SAID IT STARTED SHAKING VERY HARD AND THEN HEARD A VERY LOUD BANG. WAS ABLE TO KEEP IT UNDER CONTROL AND BRING IT TO A STOP. THERE WERE PARTS OF THE TRANSFER CASE ALL OVER THE ROAD. DRIVE SHAFT WAS BENT AT A 45 DEGREE ANGLE. WIRING WAS WRAPPED AROUND YOK”

— NHTSA complaint filing

WHEELS

2 complaints

10%

• FRONT TIRES UNEVEN WEAR, TIRE CUPPING. VIBRATION AND NOISY!
• While traveling on a highway at speeds in excess of 50mph the 2015 Ram 5500 lost the rear set of dual tires on the passenger side. The wheels came off after all 10-wheel studs failed and broke off. This is the second incident on this same truck despite going through the warranty process and procedur

Typical onset: 50K miles Est. repair: $500

“FRONT TIRES UNEVEN WEAR, TIRE CUPPING. VIBRATION AND NOISY!”

— NHTSA complaint filing

TIRES

1 complaints

• FRONT TIRES. TIRES WEAR UNEVEN. MOSTLY PASSENGER SIDE. CUPPING OF OF BOTH. NOTICEABLE VIBRATION. SAME THING HAPPENED WITH MY 2011 MODEL OF THE SAME VEHICLE.

Typical onset: 50K miles Est. repair: $500

“FRONT TIRES. TIRES WEAR UNEVEN. MOSTLY PASSENGER SIDE. CUPPING OF OF BOTH. NOTICEABLE VIBRATION. SAME THING HAPPENED WITH MY 2011 MODEL OF THE SAME VEHICLE.”

— NHTSA complaint filing

Estimated Repair Costs

ENGINE(~50K mi)

$500

ELECTRICAL(~50K mi)

$500

TRANSMISSION(~50K mi)

$500

WHEELS(~50K mi)

$500

TIRES(~50K mi)

$500

Estimates based on average reported repair costs. Actual costs vary by location, shop, and severity.

🔍 Pre-Purchase Inspection Checklist

Based on 20 owner complaints for this specific year, here's what to check or ask about:

☐
ENGINE: TL* THE CONTACT OWNS A 2015 RAM 5500. UPON INSPECTION, THE CONTACT NOTICED COOLANT LEAKING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO FIELDS CHRYSLER JEEP DODGE-SANFORD (750 TOWNE CENTER BLVD, SANFORD, FL), BUT A LEAK COULD NOT BE FOUND. AFTERWARDS, THE LOW COOLANT INDICATOR ILLUMINATED. THE CONTACT
Typically appears around 50K miles. Repair cost ~$500
☐
ELECTRICAL: BATTERY SAVER MODE MSG APPEARED ON DASH. TRUCK HAD 87,000 MILES AND 2400 HOURS. USED AS A ROADSIDE SERVICE WRECKER. TESTED BATTERIES. 1 TESTED BAD. REPLACED BOTH BATTERIES. MESSAGE COMES BACK AT STARTUP ON COLD MORNINGS. MSG STAYS ON UNTIL TRUCK IS WARMED LATER IN THE DAY.
Typically appears around 50K miles. Repair cost ~$500
☐
TRANSMISSION: TRUCK WAS ON HIGHWAY GOING 70 MPH. DRIVER SAID IT STARTED SHAKING VERY HARD AND THEN HEARD A VERY LOUD BANG. WAS ABLE TO KEEP IT UNDER CONTROL AND BRING IT TO A STOP. THERE WERE PARTS OF THE TRANSFER CASE ALL OVER THE ROAD. DRIVE SHAFT WAS BENT AT A 45 DEGREE ANGLE. WIRING WAS WRAPPED AROUND YOK
Typically appears around 50K miles. Repair cost ~$500
☐
WHEELS: FRONT TIRES UNEVEN WEAR, TIRE CUPPING. VIBRATION AND NOISY!
Typically appears around 50K miles. Repair cost ~$500
☐
General: Get a pre-purchase inspection from an independent mechanic ($100-$200)