2022 Chevrolet SUBURBAN

Problems, Recalls & Reliability Report

Below Average

Quick Summary

The 2022 Chevrolet SUBURBAN has 147 owner complaints filed with NHTSA — that's 1.8x the segment average of 80. The most common issue is engine problems (37% of all complaints), specifically: 2022 chevrolet suburban. consumer writes in regard to engine stalling, illuminated air bag light and loud rattling sound coming from the engine.. ⚠️ 2 fire reports filed.

2 fire reports 6 crash reports 5 injuries

147

Total Complaints

Recalls Issued

—/5

Safety Stars

1.8x

vs Segment Avg

Known Problems

ENGINE

54 complaints

37%

• 2022 CHEVROLET SUBURBAN. CONSUMER WRITES IN REGARD TO ENGINE STALLING, ILLUMINATED AIR BAG LIGHT AND LOUD RATTLING SOUND COMING FROM THE ENGINE.
• at some point,we noticed that every time we crank it up, the engine would sounding weird, like it was low on engine oil, we checked the engine oil, and it was no less then 2 quarts low, that was realy weird, because we change the oil as needed and we definitly make sure that we add the amount recom
• The car turned itself off while driving 55 to 60 mph on a highway. Would not turn back on after getting to the side of the road. Very dangerous.

Typical onset: 50K miles Est. repair: $500

“2022 CHEVROLET SUBURBAN. CONSUMER WRITES IN REGARD TO ENGINE STALLING, ILLUMINATED AIR BAG LIGHT AND LOUD RATTLING SOUND COMING FROM THE ENGINE.”

— NHTSA complaint filing

TRANSMISSION

28 complaints

19%

• When I started up the vehicle with the key fab button I noticed the cabin air blower came on as normal however when we went to the cockpit we noticed the engine was not running. When we went to start the vehicle (holding break and pressing start button) the dashboard started the Z71 launch sequence
• Vehicle became disabled and will not start due to failed fuel pump control module. This could be very dangerous if this would have happened in traffic; or, if vehicle occupants became stranded in an unsafe area. Vehicle must be towed to dealership to affect repair.
• Engine failure at 27k miles on a highway going highway speeds (45-50 MPH). This failure happened on a night when it was 5 degrees and dropping, vehicle full of my family + my parents. Complete engine failure, no way to run heat or move the vehicle at all. Engine failure #2 at 37k miles while drivi

Typical onset: 50K miles Est. repair: $500

“When I started up the vehicle with the key fab button I noticed the cabin air blower came on as normal however when we went to the cockpit we noticed the engine was not running. When we went to start the vehicle (holding break and pressing start button) the dashboard started the Z71 launch sequence ”

— NHTSA complaint filing

ELECTRICAL

18 complaints

12%

• When I started up the vehicle with the key fab button I noticed the cabin air blower came on as normal however when we went to the cockpit we noticed the engine was not running. When we went to start the vehicle (holding break and pressing start button) the dashboard started the Z71 launch sequence
• It was diagnosed as the Telecommunication Module, this part malfunctioned causing issues with audio in the vehicle. The audio would at times play normal, at times go completely out losing all sound to turn signals, hazard signals, and safety sensor audios inside the vehicle. It would additionally lo
• The car turned itself off while driving 55 to 60 mph on a highway. Would not turn back on after getting to the side of the road. Very dangerous.

Typical onset: 50K miles Est. repair: $500💥 1 crashes

— NHTSA complaint filing

FUEL SYSTEM

11 complaints

• When I started up the vehicle with the key fab button I noticed the cabin air blower came on as normal however when we went to the cockpit we noticed the engine was not running. When we went to start the vehicle (holding break and pressing start button) the dashboard started the Z71 launch sequence
• High pressure pump failed at 73000 miles.
• I WAS DRIVING HOME AT HIGHWAY, I HEAR NOISE SCRAPPING NOISE FROM UNEVEN PAVEMENT AND ROLL OVER SPEED BUMP AND A PIECE OF METAL LIKE U SHAPE FELT OFF. WHEN I GET HOME, INSPECTED I SAW MY VEHICLE FUEL TANK HAGGING ON ONE SIDE. FOR SAFETY TO PREVENT TANK TO FELT OFF I HAVE TO GET A STRAP TO SECURE IT T

Typical onset: 50K miles Est. repair: $500

— NHTSA complaint filing

OTHER

9 complaints

• I was driving on the interstate and my sunroof exploded. There were few cars around me and I was not under a bridge. I did not see anything coming at the car or see anything drop or fall behind us. Just heard a lot exploding noise.
• Had an issue where the main front digital cluster went black upon a start-up and drive. No speedometer, engine status, gear status or anything. Shutting the car on and off did not correct the problem. Contacted dealer and advised to bring in. I chose to disconnect the battery rebooting the vehic
• Had an issue where the left/right turn signals stopped functioning. This occurred while in-use while waiting to make a turn. Shutting the car on and off did not correct the problem. Contacted dealer and advised to bring in. I chose to disconnect the battery rebooting the vehicles BOM. Issue res

Typical onset: 50K miles Est. repair: $500

“I was driving on the interstate and my sunroof exploded. There were few cars around me and I was not under a bridge. I did not see anything coming at the car or see anything drop or fall behind us. Just heard a lot exploding noise.”

— NHTSA complaint filing

Estimated Repair Costs

ENGINE(~50K mi)

$500

TRANSMISSION(~50K mi)

$500

ELECTRICAL(~50K mi)

$500

FUEL SYSTEM(~50K mi)

$500

OTHER(~50K mi)

$500

Estimates based on average reported repair costs. Actual costs vary by location, shop, and severity.

🔍 Pre-Purchase Inspection Checklist

Based on 147 owner complaints for this specific year, here's what to check or ask about:

☐
ENGINE: 2022 CHEVROLET SUBURBAN. CONSUMER WRITES IN REGARD TO ENGINE STALLING, ILLUMINATED AIR BAG LIGHT AND LOUD RATTLING SOUND COMING FROM THE ENGINE.
Typically appears around 50K miles. Repair cost ~$500
☐
TRANSMISSION: When I started up the vehicle with the key fab button I noticed the cabin air blower came on as normal however when we went to the cockpit we noticed the engine was not running. When we went to start the vehicle (holding break and pressing start button) the dashboard started the Z71 launch sequence
Typically appears around 50K miles. Repair cost ~$500
☐
ELECTRICAL: When I started up the vehicle with the key fab button I noticed the cabin air blower came on as normal however when we went to the cockpit we noticed the engine was not running. When we went to start the vehicle (holding break and pressing start button) the dashboard started the Z71 launch sequence
Typically appears around 50K miles. Repair cost ~$500
☐
FUEL SYSTEM: When I started up the vehicle with the key fab button I noticed the cabin air blower came on as normal however when we went to the cockpit we noticed the engine was not running. When we went to start the vehicle (holding break and pressing start button) the dashboard started the Z71 launch sequence
Typically appears around 50K miles. Repair cost ~$500
☐
General: Get a pre-purchase inspection from an independent mechanic ($100-$200)