2015 Toyota HIGHLANDER

Problems, Recalls & Reliability Report

Avoid This Year

Quick Summary

The 2015 Toyota HIGHLANDER has 245 owner complaints filed with NHTSA — that's 3.1x the segment average of 80. The most common issue is electrical problems (20% of all complaints), specifically: i parked my car in the garage and several hours later i happened to need something out there. when i entered i heard an electric motor running even though the car had been turned off for several hours. crawling under the car i found that the sound was comming from a motor near the rear axle. i repo. ⚠️ 10 fire reports filed.

10 fire reports 13 crash reports 9 injuries

245

Total Complaints

Recalls Issued

—/5

Safety Stars

3.1x

vs Segment Avg

Known Problems

ELECTRICAL

50 complaints

20%

• I PARKED MY CAR IN THE GARAGE AND SEVERAL HOURS LATER I HAPPENED TO NEED SOMETHING OUT THERE. WHEN I ENTERED I HEARD AN ELECTRIC MOTOR RUNNING EVEN THOUGH THE CAR HAD BEEN TURNED OFF FOR SEVERAL HOURS. CRAWLING UNDER THE CAR I FOUND THAT THE SOUND WAS COMMING FROM A MOTOR NEAR THE REAR AXLE. I REPO
• HELLO, I WOULD LIKE TO GET NHTSA'S HELP BECAUSE TOYOTA WON'T PROVIDE ANY REMEDY FOR THIS PROBLEM. ON 4/17/2015, I BOUGHT A TOYOTA 2015 HIGHLANDER LE PLUS FROM TOYOTA NORTH BRUNSWICK (NJ) AND NOTICED BUZZING SOUND AFTER DRIVING ONLY ~30 MINUTES. BUZZING SOUND COMES FROM DASHBOARD AREA CONSTANT
• WHILE THE VEHICLE WAS BEING DRIVEN, THE POWER CUT OUT AND A MESSAGE APPEARED ON THE DASH STATING THAT THE BRAKE AND ACCELERATOR WERE BEING DEPRESSED SIMULTANEOUSLY -- BUT THEY WERE NOT. THIS HAPPENED THREE TIMES IN A ROW. WE HAD THE VEHICLE TOWARD TO THE TOYOTA DEALER WHERE PURCHASED. THEY COULD N

Typical onset: 50K miles Est. repair: $500🔥 4 fire reports

“I PARKED MY CAR IN THE GARAGE AND SEVERAL HOURS LATER I HAPPENED TO NEED SOMETHING OUT THERE. WHEN I ENTERED I HEARD AN ELECTRIC MOTOR RUNNING EVEN THOUGH THE CAR HAD BEEN TURNED OFF FOR SEVERAL HOURS. CRAWLING UNDER THE CAR I FOUND THAT THE SOUND WAS COMMING FROM A MOTOR NEAR THE REAR AXLE. I REPO”

— NHTSA complaint filing

OTHER

43 complaints

18%

• THE DASH READOUT FOR MPH BEGAN SHOWING VERY ERRATIC NMBERS. GOING FROM 24.4 MPG TO 29.7 MPG AND DOWN TO 13.1 MPG ALL IN A SPAN OF ABOUT 4 MILES. THIS MPG OF 24.4 WAS FOR THE PRIOR 3000 MILES. THE DEALER COULD NOT REPLICATE THIS HAPPENING. THEY ALSO SAID THAT TOYOTA HAD NO BULLETINS FOR THIS MATTER
• PICKED UP 2015 TOYOTA HIGHLANDER FROM THE DEALER DROVE IT HOME. OPERATED THE CAR FOR ONE DAY, PARKED IT IN THE GARAGE AND LATER HAD A FIRE IN THE GARAGE THAT DESTROYED THE HOUSE AND 2 OTHER VEHICLES . AS THE CAUSE OF THE FIRE IS STILL "UNDETERMINED" SEVERAL FIRE INSPECTOR 'S I SPOKE WITH "SUSPE
• WHILE TRAVELLING ON INTERSTATE 25 NEAR FORT COLLINS, COLORADO, OUR TOYOTA HIGHLANDER'S CLOSED PANORAMIC SUNROOF SHATTERED. WE WERE TRAVELLING AT A SPEED OF 75 MPH ON A CLOUDY DAY WITH NO OBSTACLES OR FLYING DEBRIS NOTICED. THIS IS A NEW 2015 TOYOTA HIGHLANDER THAT WE HAVE ONLY BEEN DRIVING 4 MONTHS.

Typical onset: 50K miles Est. repair: $500🔥 4 fire reports

“THE DASH READOUT FOR MPH BEGAN SHOWING VERY ERRATIC NMBERS. GOING FROM 24.4 MPG TO 29.7 MPG AND DOWN TO 13.1 MPG ALL IN A SPAN OF ABOUT 4 MILES. THIS MPG OF 24.4 WAS FOR THE PRIOR 3000 MILES. THE DEALER COULD NOT REPLICATE THIS HAPPENING. THEY ALSO SAID THAT TOYOTA HAD NO BULLETINS FOR THIS MATTER ”

— NHTSA complaint filing

BODY/STRUCTURE

27 complaints

11%

• TL*THE CONTACT OWNS A 2015 TOYOTA HIGHLANDER. THE CONTACT STATED THAT DURING INCLEMENT WEATHER, WATER LEAKED INSIDE THE VEHICLE THROUGH THE MOLDING ON THE FRONT DRIVER AND PASSENGER DOORS. THE CONTACT STATED THAT THE MOLDING WAS NOT SEALED PROPERLY TO PREVENT WATER FROM LEAKING IN. THE FAILURE RECUR
• THIS HIGHLANDER HAS A POWER LIFTGATE. IF A CHILD OR ADULT GETS IN THE WAY OF THE LIFTGATE WHEN IT IS LOWERING, THE CHILD OR ADULT CAN BE SERIOUSLY INJURED, CRUSHED OR KILLED BECAUSE THE LIFTGATE HAS NO EASY REVERSING FEATURE. IT DOES REVERSE WHEN IT HITS AN OBJECT BUT THE FORCE REQUIRED TO MAKE
• TL* THE CONTACT OWNS A 2015 TOYOTA HIGHLANDER. WHILE DRIVING APPROXIMATELY 40 MPH, THE SUBFRAME FRACTURED DUE TO THE REAR BOLTS ON THE FRAME BEING TOO TIGHT. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE REAR BOLTS WERE NOT PROPERLY INSTALLED FROM THE FACTORY ASSOCIATED WITH THE

Typical onset: 50K miles Est. repair: $500💥 1 crashes

“TL*THE CONTACT OWNS A 2015 TOYOTA HIGHLANDER. THE CONTACT STATED THAT DURING INCLEMENT WEATHER, WATER LEAKED INSIDE THE VEHICLE THROUGH THE MOLDING ON THE FRONT DRIVER AND PASSENGER DOORS. THE CONTACT STATED THAT THE MOLDING WAS NOT SEALED PROPERLY TO PREVENT WATER FROM LEAKING IN. THE FAILURE RECUR”

— NHTSA complaint filing

STEERING

25 complaints

10%

• I RECEIVED A RECALL NOTICE IN THE MAIL ON MAY 12 ABOUT A POSSIBLE DEFECTIVE CIRCUIT BOARD FOR THE ELECTRIC POWER STEERING. I TOOK THE CAR TO A TOYOTA DEALER ON MAY 13, AND WAS TOLD LATER THAT DAY THAT MY CAR DID INDEED HAVE ONE OF THE UNITS DEEMED DEFECTIVE. I WAS GIVEN A LOANER CAR AT NO CHARGE. EV
• A SAFETY RECALL ON A POSSIBLE DEFECTIVE CIRCUIT BOARD FOR THE ELECTRIC POWER STEERING, I WAS TOLD THAT THERE IS NO PARTS AVAILABLE TO REPLACE THE DEFECTIVE PARTS AND THEY DON'T EVEN KNOW WHEN IS THE PARTS WILL BE AVAILABLE.
• TL* THE CONTACT OWNS A 2015 TOYOTA HIGHLANDER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V144000(STEERING) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS

Typical onset: 50K miles Est. repair: $500💥 1 crashes

“I RECEIVED A RECALL NOTICE IN THE MAIL ON MAY 12 ABOUT A POSSIBLE DEFECTIVE CIRCUIT BOARD FOR THE ELECTRIC POWER STEERING. I TOOK THE CAR TO A TOYOTA DEALER ON MAY 13, AND WAS TOLD LATER THAT DAY THAT MY CAR DID INDEED HAVE ONE OF THE UNITS DEEMED DEFECTIVE. I WAS GIVEN A LOANER CAR AT NO CHARGE. EV”

— NHTSA complaint filing

BRAKES

15 complaints

• CLUNKING NOISE FROM REAR END OF VEHICLE WHEN BRAKING, DEALER WAS AUTHORIZED TO CHANGE REAR AWAY BARS AND SHOCKS, NO FIX, NOW TOYOTA CORP., SAYS THIS IS NORMAL CHARACTERISTIC OF VEHICLE ? I DON'T FEEL SAFE DRIVING VEHICLE WITH NOISE, AND AS BRAKES FEEL SOFT ALSO.
• POPPING SOUND COMING FROM RIGHT FRONT SIDE WHEN BREAKING TO A STOP AT ALL SPEEDS. THE PROBLEM WAS FIRST NOTICED AT AROUND 2500 MILES AND THE CAR WAS TAKEN TO THE DEALER AT AROUND 2900 MILES. DEALER INSPECTED IT AND COULDN'T FIND WHAT THE PROBLEM WAS. THEN AS INSTRUCTED BY TOYOTA REPLACED THE RIGHT
• WHILE THE VEHICLE WAS BEING DRIVEN, THE POWER CUT OUT AND A MESSAGE APPEARED ON THE DASH STATING THAT THE BRAKE AND ACCELERATOR WERE BEING DEPRESSED SIMULTANEOUSLY -- BUT THEY WERE NOT. THIS HAPPENED THREE TIMES IN A ROW. WE HAD THE VEHICLE TOWARD TO THE TOYOTA DEALER WHERE PURCHASED. THEY COULD N

Typical onset: 50K miles Est. repair: $500💥 5 crashes

“CLUNKING NOISE FROM REAR END OF VEHICLE WHEN BRAKING, DEALER WAS AUTHORIZED TO CHANGE REAR AWAY BARS AND SHOCKS, NO FIX, NOW TOYOTA CORP., SAYS THIS IS NORMAL CHARACTERISTIC OF VEHICLE ? I DON'T FEEL SAFE DRIVING VEHICLE WITH NOISE, AND AS BRAKES FEEL SOFT ALSO.”

— NHTSA complaint filing

Estimated Repair Costs

ELECTRICAL(~50K mi)

$500

OTHER(~50K mi)

$500

BODY/STRUCTURE(~50K mi)

$500

STEERING(~50K mi)

$500

BRAKES(~50K mi)

$500

Estimates based on average reported repair costs. Actual costs vary by location, shop, and severity.

🔍 Pre-Purchase Inspection Checklist

Based on 245 owner complaints for this specific year, here's what to check or ask about:

☐
ELECTRICAL: I PARKED MY CAR IN THE GARAGE AND SEVERAL HOURS LATER I HAPPENED TO NEED SOMETHING OUT THERE. WHEN I ENTERED I HEARD AN ELECTRIC MOTOR RUNNING EVEN THOUGH THE CAR HAD BEEN TURNED OFF FOR SEVERAL HOURS. CRAWLING UNDER THE CAR I FOUND THAT THE SOUND WAS COMMING FROM A MOTOR NEAR THE REAR AXLE. I REPO
Typically appears around 50K miles. Repair cost ~$500
☐
OTHER: THE DASH READOUT FOR MPH BEGAN SHOWING VERY ERRATIC NMBERS. GOING FROM 24.4 MPG TO 29.7 MPG AND DOWN TO 13.1 MPG ALL IN A SPAN OF ABOUT 4 MILES. THIS MPG OF 24.4 WAS FOR THE PRIOR 3000 MILES. THE DEALER COULD NOT REPLICATE THIS HAPPENING. THEY ALSO SAID THAT TOYOTA HAD NO BULLETINS FOR THIS MATTER
Typically appears around 50K miles. Repair cost ~$500
☐
BODY/STRUCTURE: TL*THE CONTACT OWNS A 2015 TOYOTA HIGHLANDER. THE CONTACT STATED THAT DURING INCLEMENT WEATHER, WATER LEAKED INSIDE THE VEHICLE THROUGH THE MOLDING ON THE FRONT DRIVER AND PASSENGER DOORS. THE CONTACT STATED THAT THE MOLDING WAS NOT SEALED PROPERLY TO PREVENT WATER FROM LEAKING IN. THE FAILURE RECUR
Typically appears around 50K miles. Repair cost ~$500
☐
STEERING: I RECEIVED A RECALL NOTICE IN THE MAIL ON MAY 12 ABOUT A POSSIBLE DEFECTIVE CIRCUIT BOARD FOR THE ELECTRIC POWER STEERING. I TOOK THE CAR TO A TOYOTA DEALER ON MAY 13, AND WAS TOLD LATER THAT DAY THAT MY CAR DID INDEED HAVE ONE OF THE UNITS DEEMED DEFECTIVE. I WAS GIVEN A LOANER CAR AT NO CHARGE. EV
Typically appears around 50K miles. Repair cost ~$500
☐
General: Get a pre-purchase inspection from an independent mechanic ($100-$200)