2025 Ford RANGER

Problems, Recalls & Reliability Report

Above Average

Quick Summary

The 2025 Ford RANGER has 47 owner complaints filed with NHTSA — that's 0.6x the segment average of 80. The most common issue is transmission problems (15% of all complaints), specifically: this truck looses power whenever someone changes lanes in front of your car. this happens even if adaptive cruise control and emergency braking is off. when someone changes lanes in front of you, even if they are going the same speed or faster, your car loses all power for 2-3 seconds, even if you a.

5 crash reports 2 injuries

Total Complaints

Recalls Issued

—/5

Safety Stars

0.6x

vs Segment Avg

Known Problems

TRANSMISSION

7 complaints

15%

• This truck looses power whenever someone changes lanes in front of your car. This happens even if adaptive cruise control and emergency braking is off. When someone changes lanes in front of you, even if they are going the same speed or faster, your car loses all power for 2-3 seconds, even if you a
• Vehicle failed to accelerate multiple times. Reduced engine power (limp mode) activated. It is available for inspection. This is a a safety risk as merging and suddenly not able to accelerate puts lives in danger. The problem was reproduced by the dealership and after the dealership thought they fix
• My 2025 Ford Ranger Lariat FX4 has experienced sudden and complete loss of accelerator pedal response while driving at low speed on at least 4 to 6 separate occasions. The engine continues to run normally, but pressing the accelerator produces no power and no vehicle response. The condition has cons

Typical onset: 50K miles Est. repair: $500

“This truck looses power whenever someone changes lanes in front of your car. This happens even if adaptive cruise control and emergency braking is off. When someone changes lanes in front of you, even if they are going the same speed or faster, your car loses all power for 2-3 seconds, even if you a”

— NHTSA complaint filing

ENGINE

7 complaints

15%

• I was driving my truck home on 01/22/26 and experienced a lack of acceleration and smelled oil. I got the truck home and looked under the hood. I noticed a collapsed rubber hose leading from the air intake box to the air intake of the turbo. I removed the air filter, which is practically new, and no
• A strong smell of burning oil is coming from the engine compartment after truck warms up. Checked fluid levels, monitoring temperature. Went to dealer, dealer claims nothing found. Went back to dealer on 031626 for concern, dealer states no problem found, all fluid levels ok. No troubleshooting perf
• My 2025 Ford Ranger Lariat FX4 has experienced sudden and complete loss of accelerator pedal response while driving at low speed on at least 4 to 6 separate occasions. The engine continues to run normally, but pressing the accelerator produces no power and no vehicle response. The condition has cons

Typical onset: 50K miles Est. repair: $500

“I was driving my truck home on 01/22/26 and experienced a lack of acceleration and smelled oil. I got the truck home and looked under the hood. I noticed a collapsed rubber hose leading from the air intake box to the air intake of the turbo. I removed the air filter, which is practically new, and no”

— NHTSA complaint filing

BRAKES

6 complaints

13%

• The brake pedal sits too high and there are obstructions under the dashboard. I'm a size 10.5 shoe, when transitioning from gas to brake, I need to lift my foot, then when transitioning the top of my foot left, it hits braces/panels under the dash and delays my braking. It's possible under the worst
• The contact owns a 2025 Ford Ranger. The contact stated that while starting the vehicle, there were several warning lights illuminated with an abnormal beeping sound coming from the vehicle. The vehicle was taken to the dealer. The dealer was informed to open the doors, turn off and restart the vehi
• The contact owns a 2025 Ford Ranger. The contact stated that while her son was operating the vehicle, the message "Brake Failure" was displayed. The vehicle was taken to the local dealer who diagnosed the vehicle and determined that the ABS Module had failed, and a software update was needed. The ve

Typical onset: 50K miles Est. repair: $500💥 1 crashes

“The brake pedal sits too high and there are obstructions under the dashboard. I'm a size 10.5 shoe, when transitioning from gas to brake, I need to lift my foot, then when transitioning the top of my foot left, it hits braces/panels under the dash and delays my braking. It's possible under the worst”

— NHTSA complaint filing

SPEED CONTROL

6 complaints

13%

• This truck looses power whenever someone changes lanes in front of your car. This happens even if adaptive cruise control and emergency braking is off. When someone changes lanes in front of you, even if they are going the same speed or faster, your car loses all power for 2-3 seconds, even if you a
• The head rest leans out so far at the top that my chin hits my chest. It doesn't matter if I try to lean the seat back of forth. Please evaluate the head rest as I believe it will cause serious injury as there is no back and forth adjustment. This can cause severe damage to the neck. You insisted
• My 2025 Ford Ranger Lariat FX4 has experienced sudden and complete loss of accelerator pedal response while driving at low speed on at least 4 to 6 separate occasions. The engine continues to run normally, but pressing the accelerator produces no power and no vehicle response. The condition has cons

Typical onset: 50K miles Est. repair: $500💥 1 crashes

— NHTSA complaint filing

ELECTRICAL

5 complaints

11%

• VIN: [XXX] Recall data refreshed on Aug 09,2025 0 Unrepaired Recalls associated with this VIN Please Amber alert the following for NATIONAL BROADCAST NHTSA 2025 Ranger Safety Recalls* Inspect seat bolt presence and torque - recall is unable to be performed at this time. Please check the fsa land
• Check engine light for CCV emesions system.
• Became aware of open recalls circa 09.2025, and requested the parts be ordered at Ford Auto Nation (FAN) Panama City, FL. Was told by John, dealership would call when parts became available. Parts have not either been available and/or there have been no calls. Calling the dealer is ludicrous as a

Typical onset: 50K miles Est. repair: $500

“VIN: [XXX] Recall data refreshed on Aug 09,2025 0 Unrepaired Recalls associated with this VIN Please Amber alert the following for NATIONAL BROADCAST NHTSA 2025 Ranger Safety Recalls* Inspect seat bolt presence and torque - recall is unable to be performed at this time. Please check the fsa land”

— NHTSA complaint filing

Estimated Repair Costs

TRANSMISSION(~50K mi)

$500

ENGINE(~50K mi)

$500

BRAKES(~50K mi)

$500

SPEED CONTROL(~50K mi)

$500

ELECTRICAL(~50K mi)

$500

Estimates based on average reported repair costs. Actual costs vary by location, shop, and severity.

🔍 Pre-Purchase Inspection Checklist

Based on 47 owner complaints for this specific year, here's what to check or ask about:

☐
TRANSMISSION: This truck looses power whenever someone changes lanes in front of your car. This happens even if adaptive cruise control and emergency braking is off. When someone changes lanes in front of you, even if they are going the same speed or faster, your car loses all power for 2-3 seconds, even if you a
Typically appears around 50K miles. Repair cost ~$500
☐
ENGINE: I was driving my truck home on 01/22/26 and experienced a lack of acceleration and smelled oil. I got the truck home and looked under the hood. I noticed a collapsed rubber hose leading from the air intake box to the air intake of the turbo. I removed the air filter, which is practically new, and no
Typically appears around 50K miles. Repair cost ~$500
☐
BRAKES: The brake pedal sits too high and there are obstructions under the dashboard. I'm a size 10.5 shoe, when transitioning from gas to brake, I need to lift my foot, then when transitioning the top of my foot left, it hits braces/panels under the dash and delays my braking. It's possible under the worst
Typically appears around 50K miles. Repair cost ~$500
☐
SPEED CONTROL: This truck looses power whenever someone changes lanes in front of your car. This happens even if adaptive cruise control and emergency braking is off. When someone changes lanes in front of you, even if they are going the same speed or faster, your car loses all power for 2-3 seconds, even if you a
Typically appears around 50K miles. Repair cost ~$500
☐
General: Get a pre-purchase inspection from an independent mechanic ($100-$200)