2025 Chevrolet BLAZER

Problems, Recalls & Reliability Report

Above Average

Quick Summary

The 2025 Chevrolet BLAZER has 42 owner complaints filed with NHTSA — that's 0.5x the segment average of 80. The most common issue is other problems (21% of all complaints), specifically: 1).engine stopped on interstate hiway with just 2024 miles. towed to chevy dealer. new engine installed. upon return of car emission system failure. 2) car delivered with defective windshield with major (crackle) throughout very distracting at sunrise/sunset. replacement not much better..

5 crash reports 5 injuries

Total Complaints

Recalls Issued

—/5

Safety Stars

0.5x

vs Segment Avg

Known Problems

OTHER

9 complaints

21%

• 1).Engine stopped on Interstate hiway with just 2024 miles. Towed to Chevy dealer. New engine installed. Upon return of car emission system failure. 2) Car delivered with defective windshield with major (crackle) throughout very distracting at sunrise/sunset. Replacement not much better.
• the onstar is out, cant make a call to them, cant remote start on app, navigation doesnt work
• This issue is about "OnStar Telematics Control Module", since last 3 months.. mutiple services in my car stopped working. No GPS, TPS warning messages.. No internet..This issue has been reported all across US and GM, NHSTA needs to investigate this.

Typical onset: 50K miles Est. repair: $500💥 1 crashes

“1).Engine stopped on Interstate hiway with just 2024 miles. Towed to Chevy dealer. New engine installed. Upon return of car emission system failure. 2) Car delivered with defective windshield with major (crackle) throughout very distracting at sunrise/sunset. Replacement not much better.”

— NHTSA complaint filing

ELECTRICAL

7 complaints

17%

• The infotainment system of a brand new 2025 Blazer EV is doing blackouts, flickers, and changing commands and requests. While this may sound trivial - and if this system just did the radio - I would agree. However it controls most all the sub-systems of the car from Charging, to Display, to GPS,
• Published date: 09/6/2024 Preliminary Information PIT6231 Poor Sound Quality On A Phone Call GM Dealers are not recognizing this service bulletin to remedy the microphone issue. This is a life safety issue and a formal recall notice should be issued. Reason if the driver or passenger is injured in
• Telematics control module failure

Typical onset: 50K miles Est. repair: $500

“The infotainment system of a brand new 2025 Blazer EV is doing blackouts, flickers, and changing commands and requests. While this may sound trivial - and if this system just did the radio - I would agree. However it controls most all the sub-systems of the car from Charging, to Display, to GPS, ”

— NHTSA complaint filing

DRIVER ASSIST/CAMERAS

6 complaints

14%

• Just purchased a used 2025 RS EV on 5/2/2026. When I got home I found out the Google maps and on star app wasn't working. Called on star and they can't connect to the car and that the telematics module is probably bad. Checked my Chevrolet app and it reports that it hasn't connected to the car for o
• Just purchased a used 2025 RS EV on 5/2/2026. When I got home I found out the Google maps and on star app wasn't working. Called on star and they can't connect to the car and that the telematics module is probably bad. Checked my Chevrolet app and it reports that it hasn't connected to the car for o
• Complete and total failure of the telematics module resulting in loss of self driving, onstar, WiFi, gps, and all connected services. Severe battery drain due to module forcing the vehicle to completely shut down while driving, resulting in loss of power steering and brakes.

Typical onset: 50K miles Est. repair: $500💥 3 crashes

“Just purchased a used 2025 RS EV on 5/2/2026. When I got home I found out the Google maps and on star app wasn't working. Called on star and they can't connect to the car and that the telematics module is probably bad. Checked my Chevrolet app and it reports that it hasn't connected to the car for o”

— NHTSA complaint filing

BRAKES

4 complaints

10%

• On December 22, 2025, I purchased a brand-new Chevrolet Blazer EV SS from a dealership located approximately 1 hour and 10 minutes away from my home. Immediately after leaving the dealership lot, I noticed a grinding / grunting noise coming from the vehicle. This was not a minor rattle or normal “ne
• On two separate occasions the vehicle lost all power while driving. On December 5, 2025 turning on to a main road from parking lot the vehicle shut off with no prior warning lights. Shifted vehicle to park. No power to anything, unable to unlock doors, unable to turn on hazard flashers, stuck in th
• The vehicle accelerated without input and the brakes failed to respond. I am notifying you that this vehicle is a life-threatening safety risk and should not be rented again until a master technician clears the electronic throttle control and breaking system. This condition presents a serious safety

Typical onset: 50K miles Est. repair: $500💥 1 crashes

“On December 22, 2025, I purchased a brand-new Chevrolet Blazer EV SS from a dealership located approximately 1 hour and 10 minutes away from my home. Immediately after leaving the dealership lot, I noticed a grinding / grunting noise coming from the vehicle. This was not a minor rattle or normal “ne”

— NHTSA complaint filing

ENGINE

3 complaints

• 1).Engine stopped on Interstate hiway with just 2024 miles. Towed to Chevy dealer. New engine installed. Upon return of car emission system failure. 2) Car delivered with defective windshield with major (crackle) throughout very distracting at sunrise/sunset. Replacement not much better.
• The engine started acting weird in traffic going down hill on freeway. Eventually turned off turning into my driveway. No warning or engine light. Towed to dealer and is in for inspection, not sure if they can repair or if they have to replace the engine. When it arrived to dealer the engine light
• On two separate occasions the vehicle lost all power while driving. On December 5, 2025 turning on to a main road from parking lot the vehicle shut off with no prior warning lights. Shifted vehicle to park. No power to anything, unable to unlock doors, unable to turn on hazard flashers, stuck in th

Typical onset: 50K miles Est. repair: $500

— NHTSA complaint filing

Estimated Repair Costs

OTHER(~50K mi)

$500

ELECTRICAL(~50K mi)

$500

DRIVER ASSIST/CAMERAS(~50K mi)

$500

BRAKES(~50K mi)

$500

ENGINE(~50K mi)

$500

Estimates based on average reported repair costs. Actual costs vary by location, shop, and severity.

🔍 Pre-Purchase Inspection Checklist

Based on 42 owner complaints for this specific year, here's what to check or ask about:

☐
OTHER: 1).Engine stopped on Interstate hiway with just 2024 miles. Towed to Chevy dealer. New engine installed. Upon return of car emission system failure. 2) Car delivered with defective windshield with major (crackle) throughout very distracting at sunrise/sunset. Replacement not much better.
Typically appears around 50K miles. Repair cost ~$500
☐
ELECTRICAL: The infotainment system of a brand new 2025 Blazer EV is doing blackouts, flickers, and changing commands and requests. While this may sound trivial - and if this system just did the radio - I would agree. However it controls most all the sub-systems of the car from Charging, to Display, to GPS,
Typically appears around 50K miles. Repair cost ~$500
☐
DRIVER ASSIST/CAMERAS: Just purchased a used 2025 RS EV on 5/2/2026. When I got home I found out the Google maps and on star app wasn't working. Called on star and they can't connect to the car and that the telematics module is probably bad. Checked my Chevrolet app and it reports that it hasn't connected to the car for o
Typically appears around 50K miles. Repair cost ~$500
☐
BRAKES: On December 22, 2025, I purchased a brand-new Chevrolet Blazer EV SS from a dealership located approximately 1 hour and 10 minutes away from my home. Immediately after leaving the dealership lot, I noticed a grinding / grunting noise coming from the vehicle. This was not a minor rattle or normal “ne
Typically appears around 50K miles. Repair cost ~$500
☐
General: Get a pre-purchase inspection from an independent mechanic ($100-$200)