2019 Buick ENVISION

Problems, Recalls & Reliability Report

Above Average

Quick Summary

The 2019 Buick ENVISION has 32 owner complaints filed with NHTSA — that's 0.4x the segment average of 80. The most common issue is brakes problems (16% of all complaints), specifically: while driving the vehicle, the service "brake assist" light came on. i put my foot on the brake and had no brakes, then had limited brakes when slowly pumping then pedal went to the floor. that warning went off and the malfunction indicator lamp came on. i then had about 85% brakes.this has happe.

2 crash reports

Total Complaints

Recalls Issued

—/5

Safety Stars

0.4x

vs Segment Avg

Known Problems

BRAKES

5 complaints

16%

• WHILE DRIVING THE VEHICLE, THE SERVICE "BRAKE ASSIST" LIGHT CAME ON. I PUT MY FOOT ON THE BRAKE AND HAD NO BRAKES, THEN HAD LIMITED BRAKES WHEN SLOWLY PUMPING THEN PEDAL WENT TO THE FLOOR. THAT WARNING WENT OFF AND THE MALFUNCTION INDICATOR LAMP CAME ON. I THEN HAD ABOUT 85% BRAKES.THIS HAS HAPPE
• WHILE DRIVING THE VEHICLE, THE SERVICE "BRAKE ASSIST" LIGHT CAME ON. I PUT MY FOOT ON THE BRAKE AND HAD NO BRAKES, THEN HAD LIMITED BRAKES WHEN SLOWLY PUMPING THEN PEDAL WENT TO THE FLOOR. THAT WARNING WENT OFF AND THE MALFUNCTION INDICATOR LAMP CAME ON.
• WHILE DRIVING THE VEHICLE, THE SERVICE "BRAKE ASSIST" LIGHT CAME ON. I PUT MY FOOT ON THE BRAKE AND HAD NO BRAKES, THEN HAD LIMITED BRAKES WHEN SLOWLY PUMPING THEN PEDAL WENT TO THE FLOOR. THAT WARNING WENT OFF AND THE MALFUNCTION INDICATOR LAMP CAME ON.

Typical onset: 50K miles Est. repair: $500

“WHILE DRIVING THE VEHICLE, THE SERVICE "BRAKE ASSIST" LIGHT CAME ON. I PUT MY FOOT ON THE BRAKE AND HAD NO BRAKES, THEN HAD LIMITED BRAKES WHEN SLOWLY PUMPING THEN PEDAL WENT TO THE FLOOR. THAT WARNING WENT OFF AND THE MALFUNCTION INDICATOR LAMP CAME ON. I THEN HAD ABOUT 85% BRAKES.THIS HAS HAPPE”

— NHTSA complaint filing

OTHER

4 complaints

13%

• Paint is pealing from both sides of car strip between drivers side and passenger on both sides.
• Severe shuddering while driving. Sometimes on a smooth roadway and sometimes when crossing over a patched pothole. Shuddering continued until slowed to stop. When starting to go again car did not shudder until next incident.
• The problem started in the past year (2024-2025) with severe shuddering while driving over 35-40 mph and going over a patched pothole or other irregularity in the road. The shuddering would continue until I slowed to stop. It is quite alarming & feels like the car is falling apart and is more diffi

Typical onset: 50K miles Est. repair: $500

“Paint is pealing from both sides of car strip between drivers side and passenger on both sides.”

— NHTSA complaint filing

TIRES

3 complaints

• All 4 Michelin Premier LTX 225 / 60 R 18 tires are worn down to (on 2 tires) and below (on 2 tires) the unsafe level, where the vehicle cannot even pass an insnspection, due to safety concerns. The mileage this occurred at is 26,175 miles. These tires are “rated” by Michelin for 60,000 miles. I say
• Tires are measuring low tread (4/32in) under 27,000. At under 25,000 miles on 6/17/2022, my vehicle experienced a blowout at low speed (approx 20mph), minutes after it had been parked. No pressure sensors were alarming until the blowout occurred. I have a case with Michelin, but the dealership won't
• I'm recalling an incident I reported last year. GM refused to honor the service bulletin, and Palmen Buick GMC Cadillac in Kenosha, WI refused to work with Michelin. At 30,000 miles, I now hydroplane, and when I had my car serviced a few weeks before my warranty was set to expire, the dealership aga

Typical onset: 50K miles Est. repair: $500

“All 4 Michelin Premier LTX 225 / 60 R 18 tires are worn down to (on 2 tires) and below (on 2 tires) the unsafe level, where the vehicle cannot even pass an insnspection, due to safety concerns. The mileage this occurred at is 26,175 miles. These tires are “rated” by Michelin for 60,000 miles. I say ”

— NHTSA complaint filing

ELECTRICAL

3 complaints

• HVAC CASE DOOR MELTED. GM case #9-10542006159. Repaired 2 years ago under warranty and GM knew there was a problem with the design. The air distribution system is placed to close to the heating coils and it keeps melting. It has failed again and GM will not do anything about it and keeps saying it
• There are currently two items to report on this vehicle: 1) Failure of the gear shift. The replacement is not available for inspection. PCM found defective. The PCM was not seeing the transmission in park or neutral. The shifter assembly had to be replaced. The vehicle was not driveable and had
• The envision started losing power, the engine would not gain speed or if it did it was very slow, had the booster vacuum sensor changed, Sudden loss of power or sluggish acceleration, In the beginning the noise/whining was not loud however increased from the engine. Took to a repair shop, could no

Typical onset: 50K miles Est. repair: $500

“HVAC CASE DOOR MELTED. GM case #9-10542006159. Repaired 2 years ago under warranty and GM knew there was a problem with the design. The air distribution system is placed to close to the heating coils and it keeps melting. It has failed again and GM will not do anything about it and keeps saying it”

— NHTSA complaint filing

SUSPENSION

3 complaints

• Severe shuddering while driving. Sometimes on a smooth roadway and sometimes when crossing over a patched pothole. Shuddering continued until slowed to stop. When starting to go again car did not shudder until next incident.
• The problem started in the past year (2024-2025) with severe shuddering while driving over 35-40 mph and going over a patched pothole or other irregularity in the road. The shuddering would continue until I slowed to stop. It is quite alarming & feels like the car is falling apart and is more diffi
• I bought this vehicle used to take on a trip with my family. Drove it for a week and seemed to be fine. Got on the other side of Chicago, on interstate 80 (70mph) and the engine started shaking like an earthquake. Had to slow down fast and cross traffic to pull over. As soon as I pulled of the r

Typical onset: 50K miles Est. repair: $500

“Severe shuddering while driving. Sometimes on a smooth roadway and sometimes when crossing over a patched pothole. Shuddering continued until slowed to stop. When starting to go again car did not shudder until next incident.”

— NHTSA complaint filing

Estimated Repair Costs

BRAKES(~50K mi)

$500

OTHER(~50K mi)

$500

TIRES(~50K mi)

$500

ELECTRICAL(~50K mi)

$500

SUSPENSION(~50K mi)

$500

Estimates based on average reported repair costs. Actual costs vary by location, shop, and severity.

🔍 Pre-Purchase Inspection Checklist

Based on 32 owner complaints for this specific year, here's what to check or ask about:

☐
BRAKES: WHILE DRIVING THE VEHICLE, THE SERVICE "BRAKE ASSIST" LIGHT CAME ON. I PUT MY FOOT ON THE BRAKE AND HAD NO BRAKES, THEN HAD LIMITED BRAKES WHEN SLOWLY PUMPING THEN PEDAL WENT TO THE FLOOR. THAT WARNING WENT OFF AND THE MALFUNCTION INDICATOR LAMP CAME ON. I THEN HAD ABOUT 85% BRAKES.THIS HAS HAPPE
Typically appears around 50K miles. Repair cost ~$500
☐
OTHER: Paint is pealing from both sides of car strip between drivers side and passenger on both sides.
Typically appears around 50K miles. Repair cost ~$500
☐
TIRES: All 4 Michelin Premier LTX 225 / 60 R 18 tires are worn down to (on 2 tires) and below (on 2 tires) the unsafe level, where the vehicle cannot even pass an insnspection, due to safety concerns. The mileage this occurred at is 26,175 miles. These tires are “rated” by Michelin for 60,000 miles. I say
Typically appears around 50K miles. Repair cost ~$500
☐
ELECTRICAL: HVAC CASE DOOR MELTED. GM case #9-10542006159. Repaired 2 years ago under warranty and GM knew there was a problem with the design. The air distribution system is placed to close to the heating coils and it keeps melting. It has failed again and GM will not do anything about it and keeps saying it
Typically appears around 50K miles. Repair cost ~$500
☐
General: Get a pre-purchase inspection from an independent mechanic ($100-$200)