2019 Ford ECOSPORT

Problems, Recalls & Reliability Report

Avoid This Year

Quick Summary

The 2019 Ford ECOSPORT has 584 owner complaints filed with NHTSA — that's 7.3x the segment average of 80. The most common issue is engine problems (68% of all complaints), specifically: weird burn marks have appeared on the top of my muffler. i bought the car on march 15th, 2019. i first noticed it on april 21st, 2019 (see car doc 2 photo). i took it in to have it looked at on may 8th, when it was determined it was just a cosmetic problem. it was replaced on may 15th. today, may 24. ⚠️ 4 fire reports filed.

4 fire reports 8 crash reports 7 injuries

584

Total Complaints

Recalls Issued

—/5

Safety Stars

7.3x

vs Segment Avg

Known Problems

ENGINE

400 complaints

68%

• WEIRD BURN MARKS HAVE APPEARED ON THE TOP OF MY MUFFLER. I BOUGHT THE CAR ON MARCH 15TH, 2019. I FIRST NOTICED IT ON APRIL 21ST, 2019 (SEE CAR DOC 2 PHOTO). I TOOK IT IN TO HAVE IT LOOKED AT ON MAY 8TH, WHEN IT WAS DETERMINED IT WAS JUST A COSMETIC PROBLEM. IT WAS REPLACED ON MAY 15TH. TODAY, MAY 24
• WHILE ON A LONG TRIP I STOPPED ON A SERVICE AREA. WHEN I GOT OFF THE VEHICLE I NOTICED A STRONG HEAT SMELL. WHEN OPEN HOOD I NOTICED TURBO WAS GLOWING RED TOT ALL THE WAY BELOW OXIGEN SENSOR.
• I WAS A STOP LIGHT AND THE VEHICLE SUDDENLY SHUT OFF AND WOULD NOT LET ME RESTART IT. AFTER AWHILE AND A FEW WARNING SYSTEMS THE VEHICLE FINALLY TURNED OVER. AFTER THAT THE ENGINE LIGHT CAME ON AND THE VEHICLE STARTED TO RUN A DIAGNOSTICS WHICH I WAS UNABLE TO SEE. AS I BEGIN TO DRIVE AGAIN THE VEHI

Typical onset: 50K miles Est. repair: $500🔥 2 fire reports💥 2 crashes

“WEIRD BURN MARKS HAVE APPEARED ON THE TOP OF MY MUFFLER. I BOUGHT THE CAR ON MARCH 15TH, 2019. I FIRST NOTICED IT ON APRIL 21ST, 2019 (SEE CAR DOC 2 PHOTO). I TOOK IT IN TO HAVE IT LOOKED AT ON MAY 8TH, WHEN IT WAS DETERMINED IT WAS JUST A COSMETIC PROBLEM. IT WAS REPLACED ON MAY 15TH. TODAY, MAY 24”

— NHTSA complaint filing

TRANSMISSION

49 complaints

• WHEN SHIFTING FROM REVERSE INTO DRIVE THE TRANSMISSION SLIPS RESULTING IN THE CAR JUMPING FORWARD. SOMETIMES IT ONLY STUMBLES AND IS BARELY NOTICEABLE. OTHER TIMES IT JUMPS FORWARD SEVERAL FEET. I TOOK IT BACK TO THE DEALERSHIP WHERE I BOUGHT IT AND WE DROVE ANOTHER BRAND NEW CAR THAT HAD THE SAM
• I have tried multiple times to reach Ford Corporate since 6-6-22. They say they called me and there was not voicemail option so they closed my case. I keep opening case numbers with them. On Jun2 2nd, my car was parked, idling in the driveway on an incline. I opened the driver's side door and pushe
• Since I leased this car, I’ve had three transmission replacements, a full wiring harness replacement, numerous electrical issues with the display, and now can’t drive it due to engine low oil pressure. This car is nothing but a nightmare.

Typical onset: 50K miles Est. repair: $500🔥 1 fire reports💥 1 crashes

“WHEN SHIFTING FROM REVERSE INTO DRIVE THE TRANSMISSION SLIPS RESULTING IN THE CAR JUMPING FORWARD. SOMETIMES IT ONLY STUMBLES AND IS BARELY NOTICEABLE. OTHER TIMES IT JUMPS FORWARD SEVERAL FEET. I TOOK IT BACK TO THE DEALERSHIP WHERE I BOUGHT IT AND WE DROVE ANOTHER BRAND NEW CAR THAT HAD THE SAM”

— NHTSA complaint filing

FUEL SYSTEM

33 complaints

• I am a new owner within the first year of purchase from Enterprise Car Sales. In the last two -three months when I am driving I smell gasoline inside the car which eventually go's away after 10 -15 minutes. I notice these events when my SUV runs over a pot hole, when accelerating downhill on the fr
• While driving on the freeway going roughly 68mph, a maintenance notice came on my dash stating “Engine oil pressure low”. Prior to this, the car ran fine and there were no lights on the dash. Soon after the oil light came on (despite the oil being changed less than a month prior), followed by the ma
• My vehicle suddenly lost power while I was on the interstate in the middle of heavy traffic. The message on the screen said low oil pressure. I managed to get out of traffic and exited the highway as soon as I could. I managed to get back to town before the vehicle stopped. I had to have it towe

Typical onset: 50K miles Est. repair: $500

“I am a new owner within the first year of purchase from Enterprise Car Sales. In the last two -three months when I am driving I smell gasoline inside the car which eventually go's away after 10 -15 minutes. I notice these events when my SUV runs over a pot hole, when accelerating downhill on the fr”

— NHTSA complaint filing

OTHER

29 complaints

• I PURCHASED VEHICLE OCTOBER 2019 AND ASKED PREOWNED DEALERSHIP THE NEXT DAY I PURCHASED ABOUT THE ISSUE I HAVE: MY VEHICLE HAS DELAYED ACCELERATION AND JERKS ITS WAY THROUGH GEARS WHEN I AM MOVING AT STOP LIGHT OR BACKING UP FROM PARKING SPACE. ALSO STEERING GEAR SHAKES AND ASKED THEM IF IT WAS AN A
• I have tried multiple times to reach Ford Corporate since 6-6-22. They say they called me and there was not voicemail option so they closed my case. I keep opening case numbers with them. On Jun2 2nd, my car was parked, idling in the driveway on an incline. I opened the driver's side door and pushe
• The car will suddenly slow down. I will be going 65 miles an hour then the car will slow down to 30 miles an hour when attempting to speed up the car will start jerking and the engine will rev, but the car will not go any faster. Then the car will jolt forward unexpectedly.

Typical onset: 50K miles Est. repair: $500💥 1 crashes

“I PURCHASED VEHICLE OCTOBER 2019 AND ASKED PREOWNED DEALERSHIP THE NEXT DAY I PURCHASED ABOUT THE ISSUE I HAVE: MY VEHICLE HAS DELAYED ACCELERATION AND JERKS ITS WAY THROUGH GEARS WHEN I AM MOVING AT STOP LIGHT OR BACKING UP FROM PARKING SPACE. ALSO STEERING GEAR SHAKES AND ASKED THEM IF IT WAS AN A”

— NHTSA complaint filing

ELECTRICAL

18 complaints

• I WAS A STOP LIGHT AND THE VEHICLE SUDDENLY SHUT OFF AND WOULD NOT LET ME RESTART IT. AFTER AWHILE AND A FEW WARNING SYSTEMS THE VEHICLE FINALLY TURNED OVER. AFTER THAT THE ENGINE LIGHT CAME ON AND THE VEHICLE STARTED TO RUN A DIAGNOSTICS WHICH I WAS UNABLE TO SEE. AS I BEGIN TO DRIVE AGAIN THE VEHI
• The contact owns a 2019 Ford Ecosport. The contact stated that while driving at an undisclosed speed, the brakes seized and the vehicle lost motive power. The check engine, battery, and ABS warning lights were illuminated. The contact replaced the battery; however, the failure recurred. The vehicle
• Since I leased this car, I’ve had three transmission replacements, a full wiring harness replacement, numerous electrical issues with the display, and now can’t drive it due to engine low oil pressure. This car is nothing but a nightmare.

Typical onset: 50K miles Est. repair: $500🔥 1 fire reports

“I WAS A STOP LIGHT AND THE VEHICLE SUDDENLY SHUT OFF AND WOULD NOT LET ME RESTART IT. AFTER AWHILE AND A FEW WARNING SYSTEMS THE VEHICLE FINALLY TURNED OVER. AFTER THAT THE ENGINE LIGHT CAME ON AND THE VEHICLE STARTED TO RUN A DIAGNOSTICS WHICH I WAS UNABLE TO SEE. AS I BEGIN TO DRIVE AGAIN THE VEHI”

— NHTSA complaint filing

Estimated Repair Costs

ENGINE(~50K mi)

$500

TRANSMISSION(~50K mi)

$500

FUEL SYSTEM(~50K mi)

$500

OTHER(~50K mi)

$500

ELECTRICAL(~50K mi)

$500

Estimates based on average reported repair costs. Actual costs vary by location, shop, and severity.

🔍 Pre-Purchase Inspection Checklist

Based on 584 owner complaints for this specific year, here's what to check or ask about:

☐
ENGINE: WEIRD BURN MARKS HAVE APPEARED ON THE TOP OF MY MUFFLER. I BOUGHT THE CAR ON MARCH 15TH, 2019. I FIRST NOTICED IT ON APRIL 21ST, 2019 (SEE CAR DOC 2 PHOTO). I TOOK IT IN TO HAVE IT LOOKED AT ON MAY 8TH, WHEN IT WAS DETERMINED IT WAS JUST A COSMETIC PROBLEM. IT WAS REPLACED ON MAY 15TH. TODAY, MAY 24
Typically appears around 50K miles. Repair cost ~$500
☐
TRANSMISSION: WHEN SHIFTING FROM REVERSE INTO DRIVE THE TRANSMISSION SLIPS RESULTING IN THE CAR JUMPING FORWARD. SOMETIMES IT ONLY STUMBLES AND IS BARELY NOTICEABLE. OTHER TIMES IT JUMPS FORWARD SEVERAL FEET. I TOOK IT BACK TO THE DEALERSHIP WHERE I BOUGHT IT AND WE DROVE ANOTHER BRAND NEW CAR THAT HAD THE SAM
Typically appears around 50K miles. Repair cost ~$500
☐
FUEL SYSTEM: I am a new owner within the first year of purchase from Enterprise Car Sales. In the last two -three months when I am driving I smell gasoline inside the car which eventually go's away after 10 -15 minutes. I notice these events when my SUV runs over a pot hole, when accelerating downhill on the fr
Typically appears around 50K miles. Repair cost ~$500
☐
OTHER: I PURCHASED VEHICLE OCTOBER 2019 AND ASKED PREOWNED DEALERSHIP THE NEXT DAY I PURCHASED ABOUT THE ISSUE I HAVE: MY VEHICLE HAS DELAYED ACCELERATION AND JERKS ITS WAY THROUGH GEARS WHEN I AM MOVING AT STOP LIGHT OR BACKING UP FROM PARKING SPACE. ALSO STEERING GEAR SHAKES AND ASKED THEM IF IT WAS AN A
Typically appears around 50K miles. Repair cost ~$500
☐
General: Get a pre-purchase inspection from an independent mechanic ($100-$200)