2020 Mitsubishi OUTLANDER

Problems, Recalls & Reliability Report

Above Average

Quick Summary

The 2020 Mitsubishi OUTLANDER has 44 owner complaints filed with NHTSA — that's 0.6x the segment average of 80. The most common issue is electrical problems (25% of all complaints), specifically: while traveling on the freeway at 70mph, the car suddenly started flashing warnings of "ev system required stop safely", "rbs service required!", and the service engine soon light came on. also, i wasn't able to accelerate over 20mph. i quickly exited the freeway and turned off the car. when i resta.

7 crash reports 11 injuries

Total Complaints

Recalls Issued

—/5

Safety Stars

0.6x

vs Segment Avg

Known Problems

ELECTRICAL

11 complaints

25%

• WHILE TRAVELING ON THE FREEWAY AT 70MPH, THE CAR SUDDENLY STARTED FLASHING WARNINGS OF "EV SYSTEM REQUIRED STOP SAFELY", "RBS SERVICE REQUIRED!", AND THE SERVICE ENGINE SOON LIGHT CAME ON. ALSO, I WASN'T ABLE TO ACCELERATE OVER 20MPH. I QUICKLY EXITED THE FREEWAY AND TURNED OFF THE CAR. WHEN I RESTA
• Touch screen radio stopped working by touch reported the problem and was told by our dealer they couldn’t fix it it had to go to another dealer. That dealer said they could fix it and sent us back by the time they had time for us the warranty was out and they want us to pay for it after only 2 years
• In less than 60k miles since manufacture of the vehicle, the infotainment screen began to be insensitive to touch. 6k miles later it no longer works. During that time it was inconsistently working. This is a safety issue due to the driver focusing their eyes on the infotainment screen, while repe

Typical onset: 50K miles Est. repair: $500

“WHILE TRAVELING ON THE FREEWAY AT 70MPH, THE CAR SUDDENLY STARTED FLASHING WARNINGS OF "EV SYSTEM REQUIRED STOP SAFELY", "RBS SERVICE REQUIRED!", AND THE SERVICE ENGINE SOON LIGHT CAME ON. ALSO, I WASN'T ABLE TO ACCELERATE OVER 20MPH. I QUICKLY EXITED THE FREEWAY AND TURNED OFF THE CAR. WHEN I RESTA”

— NHTSA complaint filing

OTHER

8 complaints

18%

• 2020 MITSUBISHI OUTLANDER WAS STRUCK IN THE REAR END AND SLAMMED AGAINST A SOLID FOUNDATION IN THE FRONT THAT CAUSE THE DASHBOARD TO BREAK AND ALL THE SEATS TO BREAK FROM THE FLOOR OF THE CAR. THE AIRBAGS DID NOT DEPLOY AND SEVERE INJURIES RESULTED. THE VEHICLE WAS STATIONARY ON THE HIGHWAY IN ROUTE
• I was at a 24 hr storage unit. It was dim & I needed to unload from the rear hatch door so I backed to the open storage unit door in its upright position as high as I could get it & stopped at a safe distance from the doorway so the car door would not catch the storage unit door. I put the vehicle
• After reversing out of say the drive way or parking spot there is a thump noise after putting the car into drive and proceeding to go. I have taken it to the dealer and they state multiple people are experiencing the same thing and that they have been in contact with Mitsubishi about it and they say

Typical onset: 50K miles Est. repair: $500💥 2 crashes

“2020 MITSUBISHI OUTLANDER WAS STRUCK IN THE REAR END AND SLAMMED AGAINST A SOLID FOUNDATION IN THE FRONT THAT CAUSE THE DASHBOARD TO BREAK AND ALL THE SEATS TO BREAK FROM THE FLOOR OF THE CAR. THE AIRBAGS DID NOT DEPLOY AND SEVERE INJURIES RESULTED. THE VEHICLE WAS STATIONARY ON THE HIGHWAY IN ROUTE”

— NHTSA complaint filing

DRIVER ASSIST/CAMERAS

8 complaints

18%

• WHILE TRAVELING ON THE FREEWAY AT 70MPH, THE CAR SUDDENLY STARTED FLASHING WARNINGS OF "EV SYSTEM REQUIRED STOP SAFELY", "RBS SERVICE REQUIRED!", AND THE SERVICE ENGINE SOON LIGHT CAME ON. ALSO, I WASN'T ABLE TO ACCELERATE OVER 20MPH. I QUICKLY EXITED THE FREEWAY AND TURNED OFF THE CAR. WHEN I RESTA
• Forward collision warning light comes on with no car in front of me and car starts braking. I did see that Mitsubishi was recalling these cars with this particular problem but I have not received a recall notice.
• Got in my car to go to work and blind spot service required light came on

Typical onset: 50K miles Est. repair: $500💥 1 crashes

— NHTSA complaint filing

AIR BAGS

4 complaints

• 2020 MITSUBISHI OUTLANDER WAS STRUCK IN THE REAR END AND SLAMMED AGAINST A SOLID FOUNDATION IN THE FRONT THAT CAUSE THE DASHBOARD TO BREAK AND ALL THE SEATS TO BREAK FROM THE FLOOR OF THE CAR. THE AIRBAGS DID NOT DEPLOY AND SEVERE INJURIES RESULTED. THE VEHICLE WAS STATIONARY ON THE HIGHWAY IN ROUTE
• TL* THE CONTACT OWNS A 2020 MITSUBISHI OUTLANDER. THE CONTACT STATED WHILE ANOTHER DRIVER WAS DRIVING AT APPROXIMATELY 25-30 MPH, THE DRIVER EXPERIENCED A MEDICAL EMERGENCY AND CRASHED INTO A TREE. THE AIR BAGS FAILED TO DEPLOY. THE OCCUPANT IN THE PASSENGER'S SEAT SUSTAINED A HEAD INJURIES AND MED
• The contact owns a 2020 Mitsubishi Outlander. The contact stated that while crossing an intersection at 35 MPH; another vehicle ran a red light and crashed into the contact's front driver-side door. The contact was knocked across the two-lane road and hit a telephone pole on the passenger side of th

Typical onset: 50K miles Est. repair: $500💥 3 crashes

— NHTSA complaint filing

ENGINE

2 complaints

• WHILE TRAVELING ON THE FREEWAY AT 70MPH, THE CAR SUDDENLY STARTED FLASHING WARNINGS OF "EV SYSTEM REQUIRED STOP SAFELY", "RBS SERVICE REQUIRED!", AND THE SERVICE ENGINE SOON LIGHT CAME ON. ALSO, I WASN'T ABLE TO ACCELERATE OVER 20MPH. I QUICKLY EXITED THE FREEWAY AND TURNED OFF THE CAR. WHEN I RESTA
• The contact owns a 2020 Mitsubishi Outlander. While the contact’s wife was driving in a school zone, several unknown error codes became displayed. The Lane Departure warning light illuminated, and the automatic high beam headlights malfunctioned. While driving 70 MPH, the vehicle lost motive power,

Typical onset: 50K miles Est. repair: $500

— NHTSA complaint filing

Estimated Repair Costs

ELECTRICAL(~50K mi)

$500

OTHER(~50K mi)

$500

DRIVER ASSIST/CAMERAS(~50K mi)

$500

AIR BAGS(~50K mi)

$500

ENGINE(~50K mi)

$500

Estimates based on average reported repair costs. Actual costs vary by location, shop, and severity.

🔍 Pre-Purchase Inspection Checklist

Based on 44 owner complaints for this specific year, here's what to check or ask about:

☐
ELECTRICAL: WHILE TRAVELING ON THE FREEWAY AT 70MPH, THE CAR SUDDENLY STARTED FLASHING WARNINGS OF "EV SYSTEM REQUIRED STOP SAFELY", "RBS SERVICE REQUIRED!", AND THE SERVICE ENGINE SOON LIGHT CAME ON. ALSO, I WASN'T ABLE TO ACCELERATE OVER 20MPH. I QUICKLY EXITED THE FREEWAY AND TURNED OFF THE CAR. WHEN I RESTA
Typically appears around 50K miles. Repair cost ~$500
☐
OTHER: 2020 MITSUBISHI OUTLANDER WAS STRUCK IN THE REAR END AND SLAMMED AGAINST A SOLID FOUNDATION IN THE FRONT THAT CAUSE THE DASHBOARD TO BREAK AND ALL THE SEATS TO BREAK FROM THE FLOOR OF THE CAR. THE AIRBAGS DID NOT DEPLOY AND SEVERE INJURIES RESULTED. THE VEHICLE WAS STATIONARY ON THE HIGHWAY IN ROUTE
Typically appears around 50K miles. Repair cost ~$500
☐
DRIVER ASSIST/CAMERAS: WHILE TRAVELING ON THE FREEWAY AT 70MPH, THE CAR SUDDENLY STARTED FLASHING WARNINGS OF "EV SYSTEM REQUIRED STOP SAFELY", "RBS SERVICE REQUIRED!", AND THE SERVICE ENGINE SOON LIGHT CAME ON. ALSO, I WASN'T ABLE TO ACCELERATE OVER 20MPH. I QUICKLY EXITED THE FREEWAY AND TURNED OFF THE CAR. WHEN I RESTA
Typically appears around 50K miles. Repair cost ~$500
☐
AIR BAGS: 2020 MITSUBISHI OUTLANDER WAS STRUCK IN THE REAR END AND SLAMMED AGAINST A SOLID FOUNDATION IN THE FRONT THAT CAUSE THE DASHBOARD TO BREAK AND ALL THE SEATS TO BREAK FROM THE FLOOR OF THE CAR. THE AIRBAGS DID NOT DEPLOY AND SEVERE INJURIES RESULTED. THE VEHICLE WAS STATIONARY ON THE HIGHWAY IN ROUTE
Typically appears around 50K miles. Repair cost ~$500
☐
General: Get a pre-purchase inspection from an independent mechanic ($100-$200)